1KD-FTV ENGINE CONTROL SYSTEM
DIAGNOSTIC TROUBLE CODE CHART(2006/08 - 2008/08)
DTC Code
Detection Item
Trouble Area
MIL
Memory
See page
P0046
Turbocharger / Supercharger Boost Control Solenoid Circuit Range / Performance
- Turbocharger sub-assembly
- Turbo Motor Driver
Comes on
DTC stored
Click here
P0047
Turbocharger/Supercharger Boost Control "A" Circuit Low
- Open in DC motor circuit
- Turbo motor driver
- Turbocharger sub-assembly (DC Motor)
Comes on
DTC stored
Click here
P0048
Turbocharger/Supercharger Boost Control "A" Circuit High
- Short in DC motor circuit
- Turbo motor driver
- Turbocharger sub-assembly (DC Motor)
Comes on
DTC stored
Click here
P0069
MAP Sensor Too High or Too Low
- ECM
Comes on
DTC stored
Click here
P0087
Fuel Rail / System Pressure - Too Low
- Open or short in fuel pressure sensor circuit
- Fuel pressure sensor
- ECM
Comes on
DTC stored
Click here
P0088
Fuel Rail / System Pressure - Too High
- Supply pump (suction control valve)
- Pressure discharge valve
- Short in supply pump (suction control valve) circuit
- Open in pressure discharge valve circuit
- ECM
Comes on
DTC stored
Click here
P0093
Fuel System Leak Detected - Large Leak
- Fuel line between supply pump and common rail
- Fuel line between common rail and injector
- Supply pump
- Common rail
- Injector (P1238 is set simultaneously)
- Pressure discharge valve
- Open or short in EDU circuit (P0200 is set simultaneously)
- Open or short in injector circuit (P0200 and P1238 are set simultaneously)
- EDU (P0200 is set simultaneously)
- ECM
Comes on
DTC stored
Click here
P0095
Intake Air Temperature Sensor 2 Circuit
- Open or short in intake air temperature sensor circuit
- Intake air temperature sensor
- ECM
Comes on
DTC stored
Click here
P0097
Intake Air Temperature Sensor 2 Circuit Low
- Open or short in intake air temperature sensor circuit
- Intake air temperature sensor
- ECM
Comes on
DTC stored
Click here
P0098
Intake Air Temperature Sensor 2 Circuit High
- Open or short in intake air temperature sensor circuit
- Intake air temperature sensor
- ECM
Comes on
DTC stored
Click here
P0100
Mass or Volume Air Flow Circuit
- Open or short in mass air flow meter circuit
- Mass air flow meter
- ECM
Comes on
DTC stored
Click here
P0101
Mass or Volume Air Flow Circuit Range / Performance Problem
- Mass air flow meter
Comes on
DTC stored
Click here
P0102
Mass Air Flow Circuit Low
- Open or short in mass air flow meter circuit
- Mass air flow meter
- ECM
Comes on
DTC stored
Click here
P0103
Mass Air Flow Circuit High
- Open or short in mass air flow meter circuit
- Mass air flow meter
- ECM
Comes on
DTC stored
Click here
P0105
Manifold Absolute Pressure / Barometric Pressure Circuit
- Open or short in manifold absolute pressure sensor circuit
- Manifold absolute pressure sensor
- Turbocharger assembly
- EGR valve assembly
- ECM
Comes on
DTC stored
Click here
P0106
Manifold Absolute Pressure / Barometric Pressure Circuit Range / Performance Problem
- Manifold absolute pressure sensor
Comes on
DTC stored
Click here
P0107
Manifold Absolute Pressure / Barometric Pressure Circuit Low Input
- Open or short in manifold absolute pressure sensor circuit
- Manifold absolute pressure sensor
- Turbocharger assembly
- EGR valve assembly
- ECM
Comes on
DTC stored
Click here
P0108
Manifold Absolute Pressure / Barometric Pressure Circuit High Input
- Open or short in manifold absolute pressure sensor circuit
- Manifold absolute pressure sensor
- Turbocharger assembly
- EGR valve assembly
- ECM
Comes on
DTC stored
Click here
P0110
Intake Air Temperature Circuit
- Open or short in intake air temperature (IAT) sensor (built into MAF meter) circuit
- IAT sensor (built into MAF meter)
- ECM
Comes on
DTC stored
Click here
P0112
Intake Air Temperature Circuit Low Input
- Open or short in IAT sensor circuit
- IAT sensor (built into MAF meter)
- ECM
Comes on
DTC stored
Click here
P0113
Intake Air Temperature Circuit High Input
- Open or short in IAT sensor circuit
- IAT sensor (built into MAF meter)
- ECM
Comes on
DTC stored
Click here
P0115
Engine Coolant Temperature Circuit
- Open or short in engine coolant temperature (ECT) sensor circuit
- ECT sensor
- ECM
Comes on
DTC stored
Click here
P0116
Engine Coolant Temperature Circuit Range / Performance Problem
- Thermostat
- Engine coolant temperature (ECT) sensor
Comes on
DTC stored
Click here
P0117
Engine Coolant Temperature Circuit Low Input
- Open or short in ECT sensor circuit
- ECT sensor
- ECM
Comes on
DTC stored
Click here
P0118
Engine Coolant Temperature Circuit High Input
- Open or short in ECT sensor circuit
- ECT sensor
- ECM
Comes on
DTC stored
Click here
P0122
Throttle / Pedal Position Sensor / Switch "A" Circuit Low Input
- Throttle position sensor
- Open or short in VLU circuit
- Open in VC circuit
- ECM
Comes on
DTC stored
Click here
P0123
Throttle / Pedal Position Sensor / Switch "A" Circuit High Input
- Throttle position sensor
- Open in E2 circuit
- VC and VLU circuits are short-circuited
- ECM
Comes on
DTC stored
Click here
P0168
Fuel Temperature Too High
- Fuel temperature sensor
Comes on
DTC stored
Click here
P0180
Fuel Temperature Sensor "A" Circuit
- Open or short in fuel temperature sensor circuit
- Fuel temperature sensor
- ECM
Comes on
DTC stored
Click here
P0182
Fuel Temperature Sensor "A" Circuit Low Input
- Open or short in fuel temperature sensor circuit
- Fuel temperature sensor
- ECM
Comes on
DTC stored
Click here
P0183
Fuel Temperature Sensor "A" Circuit High Input
- Open or short in fuel temperature sensor circuit
- Fuel temperature sensor
- ECM
Comes on
DTC stored
Click here
P0190
Fuel Rail Pressure Sensor Circuit
- Open or short in fuel pressure sensor circuit
- Fuel pressure sensor
- ECM
Comes on
DTC stored
Click here
P0191
Fuel Rail Pressure Sensor Circuit Range / Performance
- Fuel pressure sensor
Comes on
DTC stored
Click here
P0192
Fuel Rail Pressure Sensor Circuit Low Input
- Open or short in fuel pressure sensor circuit
- Fuel pressure sensor
- ECM
Comes on
DTC stored
Click here
P0193
Fuel Rail Pressure Sensor Circuit High Input
- Open or short in fuel pressure sensor circuit
- Fuel pressure sensor
- ECM
Comes on
DTC stored
Click here
P0200
Injector Circuit / Open
- Open or short in injector driver (EDU) circuit
- Injector
- EDU
- ECM
Comes on
DTC stored
Click here
P0335
Crankshaft Position Sensor "A" Circuit
- Open or short in crankshaft position sensor circuit
- Crankshaft position sensor
- No.1 crankshaft position sensor plate
- ECM
Comes on
DTC stored
Click here
P0339
Crankshaft Position Sensor "A" Circuit Intermittent
- Open or short in crankshaft position sensor circuit
- Crankshaft position sensor
- No.1 crankshaft position sensor plate
- ECM
-
DTC stored
Click here
P0340
Camshaft Position Sensor "A" Circuit (Bank 1 or Single Sensor)
- Open or short in camshaft position sensor circuit
- Camshaft position sensor
- Pump drive shaft pulley
- ECM
Comes on
DTC stored
Click here
P0400
Exhaust Gas Recirculation Flow
- EGR valve stuck
- EGR valve does not move smoothly
- E-VRV (for E-EGR)
- VSV (for EGR Cut)
- E-VRV (for E-EGR) circuit
- VSV (for EGR Cut) circuit
- EGR blockage in line between exhaust manifold and intake manifold
- ECM
Comes on
DTC stored
Click here
P0405
Exhaust Gas Recirculation Sensor "A" Circuit Low
- Open or short in EGR valve position sensor circuit
- EGR valve position sensor
- ECM
Comes on
DTC stored
Click here
P0406
Exhaust Gas Recirculation Sensor "A" Circuit High
- Open or short in EGR valve position sensor circuit
- EGR valve position sensor
- ECM
Comes on
DTC stored
Click here
P0488
Exhaust Gas Recirculation Throttle Position Control Range / Performance
- Throttle valve stuck
- Throttle valve does not move smoothly
- Open or short in throttle valve circuit
- Open or short in throttle valve position sensor circuit
- Throttle position sensor (built in diesel throttle body assembly)
- ECM
Comes on
DTC stored
Click here
P0500
Vehicle Speed Sensor "A"
- Open or short in speed signal circuit
- Combination meter
- ECM
Comes on
DTC stored
Click here
P0504
Brake Switch "A" / "B" Correlation
- Short in stop light switch signal circuit
- Stop light switch
- ECM
-
DTC stored
Click here
P0560
System Voltage
- Open in back-up power source circuit
- EFI fuse
- Battery
- ECM
Comes on
DTC stored
Click here
P0606
ECM / PCM Processor
- ECM
-
DTC stored
Click here
P0607
Control Module Performance
- ECM
Comes on
DTC stored
Click here
P0617
Starter Relay Circuit High
- Park/Neutral Position (PNP) switch (A/T model)
- ST relay circuit
- Ignition switch
- ECM
Comes on
DTC stored
Click here
P0622
Generator Field "F" Terminal Circuit
- Open in generator circuit
- Generator
- ECM
Comes on
DTC stored
Click here
P0627
Fuel Pump Control Circuit / Open
- Open or short in suction control valve circuit
- Suction control valve
- ECM
Comes on
DTC stored
Click here
P1229
Fuel Pump System
- Short in supply pump (suction control valve) circuit
- Supply pump (suction control valve)
- ECM
Comes on
DTC stored
Click here
P1238
Injector Malfunction
- Injector
- EDU (P0200 is set simultaneously)
- Open or short in engine wire harness (P0200 is set simultaneously)
- Connector connection (P0200 is set simultaneously)
- Compression pressure
- Valve clearance
Comes on
DTC stored
Click here
P1251
Turbocharger / Supercharger Overboost Condition (Too High)
- Turbocharger sub-assembly
- Turbo motor driver
- Turbo motor driver power source
- Extremely low battery voltage (P0560 output simultaneously)
- Manifold absolute pressure sensor
- MAF meter
- EGR valve assembly
- Exhaust system and intake system are modified or clogged
- Turbo motor driver (momentary power cut)
- Battery voltage drop
- ECM
Comes on
DTC stored
Click here
P1264
VN Turbo Controller Malfunction
- Turbo motor driver
- Open or short in turbo motor driver circuit
- ECM
Comes on
DTC stored
Click here
P1271
Fuel Regulator Circuit Malfunction (EDU Drive)
- Open or short in pressure discharge valve circuit
- Open or short in pressure discharge valve itself
- EDU
- ECM
Comes on
DTC stored
Click here
P1272
Fuel Pressure Regulator Malfunction
- Open or short in pressure discharge valve circuit (P1271 is set simultaneously)
- Pressure discharge valve
- Supply pump
- ECM
Comes on
DTC stored
Click here
P1601
Injector Correction Circuit Malfunction (EEPROM)
- Injector compensation code
- ECM
Comes on
DTC stored
Click here
P1611
IC Circuit Malfunction
- ECM
Comes on
DTC stored
Click here
P2006
Intake Manifold Runner Control Stuck Closed (Bank 1)
- VSV for No. 1 swirl control valve
- Open or short in VSV for No. 1 swirl control valve circuit
- Intake manifold (swirl control valve)
- EGR valve assembly
- MAF meter
- Air cleaner hose
- Vacuum hose
- ECM
Comes on
DTC stored
Click here
P2009
Intake Manifold Runner Control Circuit Low (Bank 1)
- VSV for No. 1 swirl control valve
- Open in VSV for No. 1 swirl control valve circuit
- ECM
Comes on
DTC stored
Click here
P2010
Intake Manifold Runner Control Circuit High (Bank 1)
- VSV for No. 1 swirl control valve
- Short in VSV for No. 1 swirl control valve circuit
- ECM
Comes on
DTC stored
Click here
P2120
Throttle / Pedal Position Sensor / Switch "D" Circuit
- Accelerator pedal position sensor
- Accelerator pedal
- Accelerator pedal rod (arm) deformed
- ECM
Comes on
DTC stored
Click here
P2121
Throttle / Pedal Position Sensor / Switch "D" Circuit Range / Performance
- Accelerator pedal position sensor circuit
- Accelerator pedal position sensor
- ECM
Comes on
DTC stored
Click here
P2122
Throttle / Pedal Position Sensor / Switch "D" Circuit Low Input
- Accelerator pedal position sensor
- Open in VCPA circuit
- VPA circuit open or ground short
- Accelerator pedal
- Accelerator pedal rod (arm) deformed
- ECM
Comes on
DTC stored
Click here
P2123
Throttle / Pedal Position Sensor / Switch "D" Circuit High Input
- Accelerator pedal position sensor
- Open in EPA circuit
- Accelerator pedal
- Accelerator pedal rod (arm) deformed
- ECM
Comes on
DTC stored
Click here
P2125
Throttle / Pedal Position Sensor / Switch "E" Circuit
- Accelerator pedal position sensor
- Accelerator pedal
- Accelerator pedal rod (arm) deformed
- ECM
Comes on
DTC stored
Click here
P2127
Throttle / Pedal Position Sensor / Switch "E" Circuit Low Input
- Accelerator pedal position sensor
- Open in VCP2 circuit
- VPA2 circuit open or ground short
- Accelerator pedal
- Accelerator pedal rod (arm) deformed
- ECM
Comes on
DTC stored
Click here
P2128
Throttle / Pedal Position Sensor / Switch "E" Circuit High Input
- Accelerator pedal position sensor
- Open in EPA2 circuit
- Accelerator pedal
- Accelerator pedal rod (arm) deformed
- ECM
Comes on
DTC stored
Click here
P2138
Throttle / Pedal Position Sensor / Switch "D" / "E" Voltage Correlation
- VPA and VPA2 circuits are short circuited
- Accelerator pedal position sensor
- Accelerator pedal
- Accelerator pedal rod (arm) deformed
- ECM
Comes on
DTC stored
Click here
P2226
Barometric Pressure Circuit
- ECM
Comes on
DTC stored
Click here
P2228
Barometric Pressure Circuit Low Input
- ECM
Comes on
DTC stored
Click here
P2229
Barometric Pressure Circuit High Input
- ECM
Comes on
DTC stored
Click here
P245C
EGR Cooler Bypass Control Circuit Low
- VSV for No. 2 EGR valve
- Open in VSV for No. 2 EGR valve circuit
- ECM
Comes on
DTC stored
Click here
P245D
EGR Cooler Bypass Control Circuit High
- VSV for No. 2 EGR valve
- Short in VSV for No. 2 EGR valve circuit
- ECM
Comes on
DTC stored
Click here
P2563
Turbocharger/Supercharger Boost Control Position Sensor "A" Circuit Range/Performance
- Nozzle vane position sensor (Turbocharger subassembly)
Comes on
DTC stored
Click here
P2564
Turbocharger/Supercharger Boost Control Position Sensor "A" Circuit Low
- Nozzle vane position sensor (Turbocharger subassembly)
- Open or short in nozzle vane position sensor circuit
- Turbo motor driver
Comes on
DTC stored
Click here
P2565
Turbocharger/Supercharger Boost Control Position Sensor "A" Circuit High
- Nozzle vane position sensor (Turbocharger subassembly)
- Open or short in nozzle vane position sensor circuit
- Turbo motor driver
Comes on
DTC stored
Click here
P2588
Turbocharger/Supercharger Boost Control Position Sensor "B" Circuit Low
- Nozzle vane position sensor (Turbocharger subassembly)
- Open or short in nozzle vane position sensor circuit
- Turbo motor driver
Comes on
DTC stored
Click here
P2589
Turbocharger/Supercharger Boost Control Position Sensor "B" Circuit High
- Nozzle vane position sensor (Turbocharger subassembly)
- Open or short in nozzle vane position sensor circuit
- Turbo motor driver
Comes on
DTC stored
U0001
High Speed CAN Communication Bus
- Open or short in TCM and ECM circuit
- TCM
- ECM
Comes on
DTC stored
aqui estan palefo.
de la pagina
http://toyota.esealtd.com/toyota/hilux/index2.html